TGB is an incubator for eggs. Description, instructions, reviews

Many kinds of livestock today are bred by many. As most females of modern domestic breeds feathered instincts completely or partially lost, their farmers prefer to breed their pets using special incubators. In the modern market there are a variety of models of this type of equipment. In this case, the most convenient are incubators for increased hatchability of TGB.

Description of the equipment

TGB is an incubator made on a partially dismountable frame assembled from a stainless corner. The body of these devices is fabric. Inside, a special heat-insulating material and a flexible heater are laid. Thanks to this design, the temperature inside the incubator is very evenly distributed. That, of course, helps to increase the percentage of hatchability. Comfortable incubators of TGB owners of homesteads consider and because their cover is made of washable material. It is easy to care for these devices.

In general, the device is quite convenient in use and reliable - the incubator TGB. The manufacturer of this equipment is the domestic company NPP EMF. The company "Electronics for the family" has been operating on the market for more than twenty years. Its main specialization is the development and production of science-intensive household products - incubators, electromatresses, cellars, thermoregulators, etc.

Functional incubators

All models of the TGB series are equipped with a digital thermoregulator. This rather sophisticated modern device was developed on the basis of a microprocessor and has a built-in sound output stimulator function. This allows you to reduce the incubation period and simultaneously increase the percentage of hatchability. The stimulator works very simply. For some time before the withdrawal, the chicks in the egg begin to "click". The biostimulator simulates the same sounds, but at a higher frequency. As a result, the chicks begin to adjust their own biorhythm for them. As a result, the period of their development is shortened.

Another interesting feature of incubators of increased hatchability of TGB (a flexible container for household use) is aeroionization. In their design is included well-known to many devices - Chizhevsky chandelier. This device increases the number of negatively charged ions inside the incubator. As a result, the number of chicks developed but not hatching decreases. Also, under the influence of ions, the quality of the excreted young is also improved.

All models of TGB, among other things, are equipped with electronic hygrometers. These devices are designed to improve the microclimate inside the incubators. The humidity changes with the help of special rugs, floating in the troughs (by reducing or increasing their area).

Specifications

Thus, the TGB is an incubator that by functionality considerably exceeds many other models available on the market. Judging by the reviews, very good for these devices and technical characteristics:

• Capacity - up to 280 eggs;

• The maximum power is 118 watts;

• Power supply from 220 V;

• Turn trays in automatic mode - with a frequency of 2 hours;

• Size - 60 x 60 x 60 cm;

• The operating temperature in the TGB incubator can vary in the range -40 ... +90 ^о С.

Incubators TGB, among other things, can be connected to a car battery 12 V. This function is provided in case of power outages. Do not weigh these devices too much. After all, they have a tissue body, and therefore very light. The total weight of the model for 210 eggs, for example, is about 10 kg.

Modifications

By purchasing an incubator, the owner of a household farm is usually interested not only in his functional and technical characteristics. It is very important when buying also pay attention to the number of eggs the equipment is designed for. The main varieties of equipment of this brand there are only three. You can purchase models of incubators TGB for 140, 210 or 280 eggs. In one tray they fit 70 pieces. That is, in the first modification there are 2 trays, in the second - 3, and in the third - 4.

When buying a TGB incubator, among other things, you should pay attention to the labeling. The letters following the digits have this meaning:

• "A" - automatic flipping of eggs.

• "B" - the presence of a moisture meter.

• "L" is Chizhevsky's chandelier.

• "Р" - possibility of connection to the car battery.

In incubators for 140 and 210 eggs, two fans are usually installed. In the TGB model 280 there are three of them (there is an additional one at the top).

Where to put the device

Successful incubation of bird eggs on TGB equipment will only be provided the correct location of the latter. The incubator should stand in a ventilated room. That is, care should be taken to ensure that fresh air enters the ventilation openings of the device. Do not allow direct sunlight to come into the appliance. Otherwise, the temperature in the incubator will fluctuate, which is undesirable. And the device itself in this case will serve less.

According to the instructions, you can not also install equipment at open doors or windows or near heating appliances. The air temperature in the room where the incubation is carried out should be 20-25 ^o C. It is not allowed to use the device at t below 15 ^о С and above 35 ^о С.

Brief Operating Instructions

Supplied incubators TGB in disassembled form. This prevents the breakdown of the elements of their construction during transport. Therefore, before use, the device will have to be assembled, guided by the manufacturer's recommendations. The procedure is not complicated. Most likely, you just need to remove the red fastening posts fixing the rotating working chamber from the frame, and put on the cover-case. Care should be taken when assembling. The edges at the corner of the frame are quite sharp.

TGB - the incubator in use is very simple. Automatic egg turning is turned on by a small toggle switch located in the lower left corner on the frame stand. The humidity within the incubator can also be regulated, including by closing / opening the valves available on the body. The water itself is poured into a special tray, installed on the bottom of the device. The temperature required for the incubation of eggs is set on the control unit. There are also buttons for the biostimulator (0 - off, 1 - clicking sounds for chickens, 3 - for waterfowl, etc.). Isolon rug in the tray with water is placed in the second incubation period.

Bookmark the eggs

After the incubator is assembled, you need to press the toggle switch in the lower left corner of the frame and wait until the camera turns to the horizontal position. Then you can start laying eggs. For convenience, it is better to place trays almost vertically (you can use some kind of support). The egg laying is made from below with a blunt end up. If you can not completely fill the tray, you need to use a special partition. To install it, you just need to press the sides slightly. If three, but two trays are placed in the camera, they should be positioned above and below the axis of rotation. This will extend the life of the incubator. One or three trays (TGB 210) may be installed arbitrarily.

Post-Output Processing

Use TGB is possible to get young animals from any poultry. Actually, the mode of incubation itself depends on this particular species of birds being hatched. After the chicks hatch, they are given time to dry in the chamber and transplant into a warm box. Further the incubator should be processed. To do this, it simply needs to be cleaned with a sponge soaked in a disinfectant solution. Store the device best in a dry, dark and cool room.

TGB-incubators: feedback from owners of household plots

Domestic poultry producers use TGB devices quite well-deserved popularity. Many even believe that they are the best domestic incubators. Indeed, the hatchability of eggs in them is usually greater than in instruments of other brands. It's all about the rich features and excellent performance. Inside the incubator of the TGB, the microclimate is maximally favorable for the development and hatching of the chicks. At the same time, the poultry house itself is practically not monitored for anything.

Praise the owners of household plots for these devices and for the ease of assembly / disassembly, as well as for the reliability of the design. The frame of TGB incubators is made of stainless steel and can last a very long time. The same goes for the case. It is made of the strongest fabric, capable of withstanding rather serious load on the rupture. But, of course, the case of the device should be protected from various kinds of sharp objects.

What are the disadvantages

Practically complete absence of minuses - that's what distinguishes these incubators. Reviews of this device, respectively, are also good. Some poultry farmers do not like the fact that the body of the device is mounted on the frame with lightning. These devices, as you know, are not very reliable and durable.

Also, a disadvantage of TGB incubators is that eggs can not be densely packed into trays. In most cases, each series must be laid with foam rubber. If this is not done, when turning the camera during incubation, eggs can simply fall out and break.

Another minor disadvantage of TGB incubators is the sharp edges of the corner of the frame. Before assembly, those poultry farmers who have already tried TGB in the case, advised to carefully hold your finger on the metal, and then grind the file with all the sharp spots found.

TGB - egg incubator: price

To buy such a device for your garden at an ordinary store, of course, it is unlikely. This method of buying is suitable only for residents of large cities. It is easiest for other poultry farmers to order a TGB incubator via the Internet. Today there are stores selling and delivering such devices by cash on delivery. Of course, this is quite convenient.

As for the price, according to reviews, the TGB is an expensive incubator. Its cost is usually higher than that of most other domestic brands. So, for 2016 model 140 costs about 13-18 thousand rubles, depending on the functional (the presence of a moisture meter, Chizhevsky lamp, etc.). The price of the 210 can be 16-22 thousand rubles. For an incubator for 280 eggs will need to pay also about 16-22 thousand. Of course, and the delivery of such goods from afar free of charge will be unlikely (if the store is spent on transportation costs).

Thus, TGB is simply an excellent incubator for eggs. The price for this equipment, of course, is quite high. However, the functional, as well as the technical characteristics of the instruments of this brand are also very good. Those farmers who want to get quality young, think about buying it is necessary. Especially incubators of TGB will be useful for poultry farmers, who take out chicks of poultry for sale.